⌘K
Home›Chevrolet›Silverado 2500HD›2019
Chevrolet · Heavy-duty pickup

2019 Chevrolet Silverado 2500HD

Heavy-duty pickup
0 EPA-rated configurations
Data refreshed 2026-09-11
F
Safety Signal
35 / 100 from the NHTSA recall record
Recalls2 critical7
Complaintsowner reports to NHTSA74
Crash ratingNHTSA overall4★
20262025202420232022202120202019201820172016

The 2019 Chevrolet Silverado 2500HD is a heavy-duty pickup; vehicles over 8,500 lb GVWR are not certified for fuel economy by the EPA, so this page is built from NHTSA's recall, complaint and investigation records. NHTSA lists 7 recall campaigns for this model year, 2 rated critical, which gives it a Safety Signal grade of F. Owners have filed 74 complaints, most often about the engine. NHTSA crash-tested it at 4 stars overall.

Specs & fuel economy

Source: EPA fueleconomy.gov

No EPA fuel-economy record: the EPA does not certify vehicles over 8,500 lb GVWR. Recall, complaint and investigation data below come from NHTSA.

Factory warranty running out?

The 2019 Chevrolet Silverado 2500HD is in the years where transmission, electronics and drivetrain repairs land on the owner. Compare extended-coverage quotes in about two minutes.

Compare coverage →

Affiliate disclosure: some links on this page are affiliate links. If you request a quote or buy through them we may earn a commission at no extra cost to you. Nothing on this page changes because of it.

Recalls (7)

Source: NHTSA recall database
▲high

Air Bags

N262557310
4,315 vehicles
ProblemGeneral Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 vehicles. The left-side or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.RiskA detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.FixDealers will replace both RRAB modules, free of charge. Owner notification letters were mailed June 24, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262557310. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 21, 2026. This recall expands previous NHTSA recall number 26V166.
NHTSA campaign 26V325000reported May 21, 2026General Motors, LLC
▲high

Air Bags

N262549710
2,819 vehicles
ProblemGeneral Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 Crew Cab vehicles. The left or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.RiskA detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.FixDealers will replace the left and right-side RRAB modules, free of charge. Owner notification letters were mailed April 16, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262549710. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
NHTSA campaign 26V166000reported Mar 19, 2026General Motors, LLC
▲high

Air Bags

N252513060
1,658 vehicles
ProblemGeneral Motors (GM) is recalling certain 2018 GMC Sierra 1500, 2019 Sierra 2500, 3500, Chevrolet Silverado 3500, and Chevrolet Silverado 2500 and 2018 Chevrolet Silverado 1500 Crew Cab vehicles. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.RiskA detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increases the risk of injury or crash.FixDealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed July 23, 2025. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252513060.
NHTSA campaign 25V432000reported Jun 26, 2025General Motors, LLC
▲high

Air Bags

N242474500
2,061 vehicles
ProblemGeneral Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.RiskA separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.FixDealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.
NHTSA campaign 24V756000reported Oct 10, 2024General Motors, LLC
▲high

Fuel System, Diesel

N222368030
22,132 vehicles
ProblemGeneral Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.RiskAn engine stall increases the risk of a crash.FixDealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030
NHTSA campaign 23V047000reported Feb 2, 2023General Motors, LLC
!critical

Equipment

N212329840
338,020 vehicles
ProblemGeneral Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.RiskAn electrical short-circuit can increase the risk of a fire.FixDealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. In
NHTSA campaign 21V496000reported Jul 1, 2021General Motors, LLC
!critical

Engine

N182206310, -11, -12
318,374 vehicles
ProblemGeneral Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.RiskA short-circuit may damage the engine components and increase the risk of fire.FixGM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.
NHTSA campaign 19V328000reported Apr 25, 2019General Motors LLC

Owner complaints

Source: NHTSA complaint database
74complaints filed

2 involved a crash · 6 a fire · 4 injuries · 0 deaths reported

Filed per year: 2019: 11 · 2020: 13 · 2021: 5 · 2022: 6 · 2023: 9 · 2024: 13 · 2025: 7 · 2026: 10

Most-cited components

Engine19
Electrical System19
Fuel/Propulsion System10
Power Train9
Unspecified7
Service Brakes6

What owners describe

“component failed: Power steering pump and the power brake booster. Parts are available to inspect. When the component failed you begin to loose power steering and power brakes. This makes it hard to steer and brake. The vehicle was taken to the dealer who confirmed the failure of these parts and replaced them at the ow…”May 14, 2024 · Service Brakes · NHTSA owner report
“The contact owns a 2019 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the low coolant warning light illuminated. The contact stated that the warning light had been reset daily; however, the warning light illuminated daily. The vehicle was taken to the dealer and diagnosed with…”Apr 26, 2024 · Engine And Engine Cooling · NHTSA owner report
“The contact owns a 2019 Chevrolet Silverado 2500 equipped with Cooper Tires, Tire Line: Discoverer A/T3 XLT, Tire Size: 265/70/R18, DOT Number: UP511NE. The contact stated that while driving approximately 65 MPH in inclement weather, the contact heard a loud explosion, and then the vehicle swerved. The contact checked …”Feb 5, 2024 · Tires · NHTSA owner report

Complaint counts are raw owner reports to NHTSA, not verified defects, and scale with how many were sold. Use them to spot patterns, not to rank.

Crash ratings

Source: NHTSA NCAP
ConfigurationOverallFrontalSideRolloverRollover risk
PU/CC 4WD★★★★☆★★★★☆★★★★★★★★☆☆20%
PU/CC RWD★★★★☆★★★★☆★★★★★★★★☆☆20%
PU/EC 4WD★★★★☆★★★☆☆★★★★★★★★☆☆20%
PU/EC RWD★★★★☆★★★☆☆★★★★★★★★☆☆20%
PU/RC 4WD★★★★☆★★★☆☆★★★★★★★★☆☆20%
PU/RC RWD★★★★☆★★★☆☆★★★★★★★★☆☆20%

NHTSA New Car Assessment Program.

Compare the 2019 Silverado 2500HD with

2019 GMC Sierra 2500HD →2019 GMC Sierra 3500HD →2019 Ford F-250 Super Duty →2019 Ford F-350 Super Duty →2019 Ram 2500 →

Other Silverado 2500HD model years

B

2026 Chevrolet Silverado 2500HD

2 recalls · 5 complaints

A

2025 Chevrolet Silverado 2500HD

1 recalls · 28 complaints

D

2024 Chevrolet Silverado 2500HD

4 recalls · 139 complaints

A

2023 Chevrolet Silverado 2500HD

1 recalls · 46 complaints

C

2022 Chevrolet Silverado 2500HD

3 recalls · 93 complaints

F

2021 Chevrolet Silverado 2500HD

6 recalls · 84 complaints

F

2020 Chevrolet Silverado 2500HD

10 recalls · 103 complaints

F

2018 Chevrolet Silverado 2500HD

5 recalls · 52 complaints

F

2017 Chevrolet Silverado 2500HD

5 recalls · 54 complaints

D

2016 Chevrolet Silverado 2500HD

5 recalls · 123 complaints

Sources & method

Safety Signal starts every model-year at 100 and subtracts points per open NHTSA recall campaign by severity: critical 15 (fire risk, park-outside or do-not-drive advisories), high 8 (brakes, steering, airbags, loss of drive power, structure, battery), moderate 6, minor 3 (software, labels, lighting fixed by an update). Floor 35. A ≥ 90, B ≥ 80, C ≥ 70, D ≥ 60, otherwise F. Complaint counts and NHTSA crash ratings are shown separately and are not blended into the grade.

EPA figures come from fueleconomy.gov vehicle records. Recalls, complaints, investigations and crash ratings come from NHTSA's public flat files, refreshed weekly.

JSON for this page · API