Ram bulletin 9100548
What it says"ADJUSTER Seat DJ D2 DP 1st Row Power Seat Fore/Aft Adjuster Inspection TSB is also released for this concern. NHTSA’s full summary ↓
Ram filed this with NHTSA as a service bulletin dated Apr 17, 2025, about the seats. It names 14 model years (2022–2025). A service bulletin is not a safety recall: it is the manufacturer telling its dealers how to diagnose or repair a condition, and whether the work is paid for depends on the warranty in force. Quoting the number at a service desk can save a diagnosis.
Get the next Ram bulletin for your model by email Weekly, only when something new is filed. Nothing else; one-click unsubscribe.
What the bulletin says
Source: NHTSA's summary of the manufacturer's communication"ADJUSTER Seat DJ D2 DP 1st Row Power Seat Fore/Aft Adjuster Inspection TSB is also released for this concern. SYMPTOM/CONDITION: Fore-aft function does NOT work when actuating the seat switch. DIAGNOSIS: 1) Put seat in position for inspection. 2) Disconnect seat wire harness motor connector from the fore-aft motor on the seat adjuster, wait 10 seconds, and reconnect. 3) Verify function of the fore/aft adjuster. Step 1. Open 2nd row door and function rear seat cushions up to stowed position. Step 2. Adjust the driver front seat to the full up position. Use switches on the side shield to move power seat fully up. Step 3. Remove the 4 bolts that hold the seat to the truck floor and discard. The bolts have lock patch that is not reusable. Step 4. Lay the seat down so its laying on its back so the underside of the seat is easily accessible. Step 5. Remove the fore/aft wire harness motor connector from the fore/aft motor (back right of the seat adjuster). Push on the tab to remove the motor wire harness connector from the motor. Leave disconnected for 10 seconds. Step 6. Reconnect the fore/aft wire harness motor connector to the fore/aft motor. Push / Pull / Push the connector with fingers to ensure the wire harness connector is fully seated to the fore/aft motor connector. Step 7. Before assembling the seat back to the truck floor, cycle the seat to check that the motor is working properly by pressing the fore/aft switch. If fore/aft motor does not function, please refer to Replacement Procedure below. Step 8. If the seat is working properly, carefully reassemble the seat back to the truck floor using the four new bolts. Use a torque wrench to verify 47 Nm. Step 9. *Note: Checking the passenger seat will be the same procedure as the driver seat. REPLACEMENT PROCEDURE Only for seats rejected after inspection. Replace Power Seat Adjuster per MOPAR service part replacement instructions. MOPAR Part Numbers: 68455847AA, 68455848AA, 68455849AA"
Document filed under this number
| Document | Kind | Dated | NHTSA id | At NHTSA |
|---|---|---|---|---|
| 9100548 | Service bulletin | Apr 17, 2025 | 11017081 | PDF, 57 KB |
What the document itself lists
Parts the bulletin names
| Part number | Description | Qty | Find it |
|---|---|---|---|
| 68455847AA | — | — | eBay Motors → |
| 68455848AA | — | — | eBay Motors → |
| 68455849AA | — | — | eBay Motors → |
Read by machine from the document NHTSA serves (1 page), read Sep 30, 2026. A part number is shown only where it matches Ram’s own catalogue shape, an operation only with its code and time, and a description only where the reader got it whole; anything it could not settle is left out, and the PDF is the record. Times are the manufacturer’s warranty allowances, not a quote. Listings and prices on eBay Motors are the seller’s.
Affiliate disclosure: some links on this page are affiliate links. If you request a quote or buy through them we may earn a commission at no extra cost to you. Nothing on this page changes because of it.
The summary is NHTSA’s abstract of the document, as filed under 49 CFR 579.5. One communication is usually filed as several documents — the bulletin, a dealer notice, an owner letter — and the number on any of them finds this page. A PDF link is shown only once NHTSA’s own server has been seen to serve that document; the rest are checked over the following nights. Quote the number at a service desk; it is what the dealer’s system is keyed on.
Model years it names
Source: as the manufacturer filed themAlso filed against model years this site has no page for: 2022 Ram 4500; 2023 Ram 4500; 2024 Ram 4500; 2025 Ram 4500; 2022 Ram 5500; 2023 Ram 5500; 2024 Ram 5500; 2025 Ram 5500.
A vehicle page’s bulletin list shows the newest few communications filed against that model year; the count there is every one.
Email me new Ram bulletins for one of these models
A weekly email, sent only in a week when Ram files something new with NHTSA for the model you pick — service bulletins, campaigns, warranty extensions, over-the-air notices, every model year. Nothing else is sent; one-click unsubscribe in every message. Separate from recall alerts.
What owners reported
Source: NHTSA complaint databaseOwners of the 6 model years this bulletin names have filed 273 complaints with NHTSA since 2015.
A complaint is one owner’s account, not a defect finding, and a bulletin is not a recall. Nothing here says this bulletin was issued because of these complaints, or that the repair it describes fixed them. Complaint files on this site begin in 2015.
More bulletins about the seats
Source: same model, same component group5 other manufacturer communications filed against these Ram models under the same component group (seats), newest first.
| Number | Kind | Dated | NHTSA’s summary |
|---|---|---|---|
| S2508000107 | Service bulletin | Dec 12, 2025 | Comfort Seat Module (CSM) or Comfort Steering Wheel Module (CSWM) do Not Operate |
| 08-182-25 | Service bulletin | Jun 7, 2025 | "Power Seat Not Adjusting Customers may experience one or more of the following: ● Driver and/or passenger seat moves backwards but not forw… |
| 9100562 | Service bulletin | May 20, 2025 | Frame - Front Seat Back: 2024 2025 DJ D2 Power back frame with INOP motor replaced seat frame Please review TSB 08-159-25 before replacing… |
| S2310000003 | Service bulletin | Jan 4, 2025 | The customer may experience an airbag light on or seat belt chime when buckled. |
| 9100465 | Service bulletin | Dec 16, 2024 | SEAT BELT Front Outer Seatbelt Slow Retraction / Seat Belt Cleaning If the vehicle exhibits slow seatbelt retraction, prior to replacing sea… |
Quote the number at the service desk. It is what the dealer’s system is keyed on.
Every manufacturer communication NHTSA holds for Ram, by the number printed on the letter.
Common questions
Source: NHTSA, 49 CFR 579.5Is Ram 9100548 a recall?
No. A service bulletin is a manufacturer communication filed with NHTSA under 49 CFR 579.5; a safety recall carries an NHTSA campaign number (two digits, a letter, six digits) and a federal duty to repair for free. Check the vehicle’s recalls by VIN at nhtsa.gov/recalls, or on its page here.
Is the 9100548 repair free?
Not automatically. A service bulletin describes how to diagnose or repair a condition; who pays depends on the warranty in force, any extension, and the dealer. Quoting the number can save a diagnosis either way.
Which vehicles does 9100548 cover?
The manufacturer filed it against 14 model years: 2025 Ram 2500, 2024 Ram 2500, 2023 Ram 2500, 2025 Ram 3500, 2024 Ram 3500, 2023 Ram 3500 and more. Whether one particular vehicle is affected is a matter of its VIN and its build, not its model year alone.