Mercedes-Benz bulletin LI35.30-P-077843
What it saysCracking noises from the area of the rear axle 2. or a message in the instrument cluster "ESP, ABS failed". NHTSA’s full summary ↓
Mercedes-Benz filed this with NHTSA as a service bulletin dated May 16, 2024, received May 31, 2024, about the power train. It names 10 model years (2020–2024). A service bulletin is not a safety recall: it is the manufacturer telling its dealers how to diagnose or repair a condition, and whether the work is paid for depends on the warranty in force. Quoting the number at a service desk can save a diagnosis.
Get the next Mercedes-Benz bulletin for your model by email Weekly, only when something new is filed. Nothing else; one-click unsubscribe.
What the bulletin says
Source: NHTSA's summary of the manufacturer's communicationComplaint 1. Cracking noises from the area of the rear axle 2. or a message in the instrument cluster "ESP, ABS failed". Cause Anti-cracking disk at the external joint of the side shaft at the rear axle is broken. Remedy • Customer complaint due to noises: • A test drive must be performed. For a precise noise analysis (localization of the noise), make use of the NVH/PICO. If the joint of the side shaft can be clearly identified as the cause (source of the noise), the following work must be performed: 1. Remove the side shaft, check the anti-cracking disk, and remove the anti-cracking disk if it is broken, 2. then process the external joint as per LI35.30-P-058566 and reinstall the side shaft. After the processing is complete, an anti-cracking disk is no longer required. • Customer complaint due to display message "ESP, ABS failed" in the instrument cluster: • Read out the fault memory; if a rotational speed sensor of the rear axle is stored in the fault memory, the following work must be performed: 1. Check the rotational speed sensor of the affected side for damage and replace if necessary. 2. Remove the side shaft, check the anti-cracking disk, and remove the anti-cracking disk if it is broken, 3. then process the external joint as per LI35.30-P-058566 and reinstall the side shaft. After the processing is complete, an anti-cracking disk is no longer required. Note: It is not necessary to replace the side shaft.
Document filed under this number
| Document | Kind | Dated | NHTSA id | At NHTSA |
|---|---|---|---|---|
| LI35.30-P-077843 | Service bulletin | May 16, 2024 | 11000610 | PDF, 4,191 KB |
The summary is NHTSA’s abstract of the document, as filed under 49 CFR 579.5. One communication is usually filed as several documents — the bulletin, a dealer notice, an owner letter — and the number on any of them finds this page. A PDF link is shown only once NHTSA’s own server has been seen to serve that document; the rest are checked over the following nights. Quote the number at a service desk; it is what the dealer’s system is keyed on.
Model years it names
Source: as the manufacturer filed themA vehicle page’s bulletin list shows the newest few communications filed against that model year; the count there is every one.
Email me new Mercedes-Benz bulletins for one of these models
A weekly email, sent only in a week when Mercedes-Benz files something new with NHTSA for the model you pick — service bulletins, campaigns, warranty extensions, over-the-air notices, every model year. Nothing else is sent; one-click unsubscribe in every message. Separate from recall alerts.
What owners reported
Source: NHTSA complaint databaseOwners of the 10 model years this bulletin names have filed 496 complaints with NHTSA since 2015. 173 of them name Electrical System, Power Train, Service Brakes — the same broad component group this bulletin is filed under. NHTSA groups complaints coarsely, so that means the same area of the vehicle, not necessarily the same fault.
On the 2020 Mercedes-Benz GLE-Class, the 13 owners who gave an odometer reading for Electrical System reported it at a median of 6,615 miles. That figure is one model year’s, not the whole range this bulletin covers — medians from different model years are not averaged.
I am writing to formally log an urgent Safety-Critical Incident Report regarding a complete brake system failure on my 2022 Mercedes-Benz GLS450 (VIN: ). Incident Details: Date & Time：［XXX］ Vehicle Mileage: Approximate 30k miles Occupants: 5 family members (including 3 children) Maintenance History: Fully and regularly maintained…
2022 Mercedes-Benz GLS-Class · Service Brakes · filed with NHTSA Sep 14, 2026 · ODI 11763973
There have been 3 incidents where the car responded to unknown stimuli by braking hard. 3 months ago it happened while making a left turn through an intersection, driving about 10 mph the brakes unexpectedly locked up, luckily the person behind me took evasive action and didn't hit me; 2 weeks later it happened again, I was driving on…
2023 Mercedes-Benz GLS-Class · Service Brakes · filed with NHTSA Oct 2, 2024 · ODI 11617794
As I approached a red light and removed my foot from the gas pedal to brake, my dashboard displayed several alarming messages: “Active Brake Assist Functions Limited See Owner's Manual,” “Active Blind Spot Assist Inoperative,” “To Deselect P or N Depress Brake and Start Engine,” and “Traction Control Inoperative See Owner's Manual.”…
2022 Mercedes-Benz GLS-Class · Electrical System · filed with NHTSA Jun 4, 2024 · ODI 11592527
A complaint is one owner’s account, not a defect finding, and a bulletin is not a recall. Nothing here says this bulletin was issued because of these complaints, or that the repair it describes fixed them. Complaint files on this site begin in 2015.
More bulletins about the power train
Source: same model, same component group27 other manufacturer communications filed against these Mercedes-Benz models under the same component group (power train), newest first. The eight newest are listed; the rest are on the Mercedes-Benz list.
| Number | Kind | Dated | NHTSA’s summary |
|---|---|---|---|
| LI27.00-P-073124 | Service bulletin | Sep 26, 2026 | Complaint Customer complaints relating to automatic transmission 725.0 (NAG3 Classic /9G‑TRONIC automatic transmission) and 725.1… |
| NCU - 2026080002 | Service campaign | Sep 25, 2026 | Mercedes-Benz AG, the manufacturer of Mercedes-Benz vehicles, has determined that on certain subject vehicles, the transmission control unit… |
| LI35.31-P-080353 | Service bulletin | Sep 14, 2026 | Complaint Whining / humming noises (described as foghorn‑like) from the drivetrain in the rear axle area during cornering. (figure 1) On the… |
| LI27.10-P-075869 | Service bulletin | Sep 14, 2026 | Complaint Only vehicles with a variable transfer case are affected. This can be identified through control unit N45 or N15/7 in the quick te… |
| LI 27.10-P-080851 | Service bulletin | Aug 29, 2026 | Complaint Intermittent shift feel or thud/clunk noise perceived, such as a brief jerk or transmission reaction during certain driving situat… |
| LI27.00-P-075630 | Service bulletin | Aug 5, 2026 | Complaint This document is intended as a pre-case diagnostic reference for transmission related concerns. It will also ensure that if a case… |
| LI27.00-P-080840 | Service bulletin | Aug 4, 2026 | Complaint Mercedes-Benz USA is currently experiencing limited availability of transmission fluid specification ATF 236.17 due to a global su… |
| LI35.30-P-058566 | Service bulletin | Jul 14, 2026 | Complaint Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The noise is heard once… |
Quote the number at the service desk. It is what the dealer’s system is keyed on.
Every manufacturer communication NHTSA holds for Mercedes-Benz, by the number printed on the letter.
Common questions
Source: NHTSA, 49 CFR 579.5Is Mercedes-Benz LI35.30-P-077843 a recall?
No. A service bulletin is a manufacturer communication filed with NHTSA under 49 CFR 579.5; a safety recall carries an NHTSA campaign number (two digits, a letter, six digits) and a federal duty to repair for free. Check the vehicle’s recalls by VIN at nhtsa.gov/recalls, or on its page here.
Is the LI35.30-P-077843 repair free?
Not automatically. A service bulletin describes how to diagnose or repair a condition; who pays depends on the warranty in force, any extension, and the dealer. Quoting the number can save a diagnosis either way. Every Mercedes-Benz warranty extension on file lists the ones Mercedes-Benz has filed.
Which vehicles does LI35.30-P-077843 cover?
The manufacturer filed it against 10 model years: 2024 Mercedes-Benz GLE-Class, 2023 Mercedes-Benz GLE-Class, 2022 Mercedes-Benz GLE-Class, 2021 Mercedes-Benz GLE-Class, 2020 Mercedes-Benz GLE-Class, 2024 Mercedes-Benz GLS-Class and more. Whether one particular vehicle is affected is a matter of its VIN and its build, not its model year alone.