Mercedes-Benz bulletin LI27.00-N-078611
What it saysPre-Case creation for 725.0/.1 Transmissions Complaint: To insure vehicle down time is kept at a minimum and all required information is available when case is escalated, as well as assist technicians with checks… NHTSA’s full summary ↓
Mercedes-Benz filed this with NHTSA as a service bulletin dated Nov 20, 2024, received Dec 4, 2024, about the power train. It names 2 model years (2023–2024). A service bulletin is not a safety recall: it is the manufacturer telling its dealers how to diagnose or repair a condition, and whether the work is paid for depends on the warranty in force. Quoting the number at a service desk can save a diagnosis.
Get the next Mercedes-Benz Sprinter bulletin by email Weekly, only when something new is filed. Nothing else; one-click unsubscribe.
What the bulletin says
Source: NHTSA's summary of the manufacturer's communicationPre-Case creation for 725.0/.1 Transmissions Complaint: To insure vehicle down time is kept at a minimum and all required information is available when case is escalated, as well as assist technicians with checks that may help lead in resolving issue without case creation. THIS LI IS NOT TO BE USED AS A REASON FOR CASE CREATION BUT AS A GUIDE IF A CASE IS NEEDED Cause: There are, at times, additional steps workshops can do to help diagnose and rectify transmission complaints. Remedy: When opening a case for transmissions a EEPROM, Quick Test, and VGS CUL are absolutely necessary Please also check for any relevant LI’s before opening case. Also, recommend having customer fill out Transmission Drivability Diagnostic Worksheet especially if complaint is hard to reproduce or intermittent (Work sheet Location: Xentry Portal >> Local Contents >> Diagnostic Info>> Diagnostic Worksheets ) If a previous repair attempt or visit was made for the same concern please include the date, mileage, and case num- ber if applicable of that repair/visit with a short description of what was done. Follow IPR: ( LI27.00-P-073124 ) All IPR suggestions are covered by warranty and there is no need for cases to con- firm IPR. Complete IPR suggestions and close out IPR process. If complaint is not fixed and IPR still suggests the sa- me repair once closed out and run again, then a case may be needed. Transmission Health page is a good indicator of issues within transmission if clutch or brake pack stays NOK after ad- aptions and unable to be made to a green OK then an internal fault is present. Proceed with replacing affected clutch pack.
Document filed under this number
| Document | Kind | Dated | NHTSA id | At NHTSA |
|---|---|---|---|---|
| LI27.00-N-078611 | Service bulletin | Nov 20, 2024 | 11011221 | PDF, 41 KB |
The summary is NHTSA’s abstract of the document, as filed under 49 CFR 579.5. One communication is usually filed as several documents — the bulletin, a dealer notice, an owner letter — and the number on any of them finds this page. A PDF link is shown only once NHTSA’s own server has been seen to serve that document; the rest are checked over the following nights. Quote the number at a service desk; it is what the dealer’s system is keyed on.
Model years it names
Source: as the manufacturer filed themA vehicle page’s bulletin list shows the newest few communications filed against that model year; the count there is every one.
Email me new Mercedes-Benz bulletins for the Sprinter
A weekly email, sent only in a week when Mercedes-Benz files something new with NHTSA for the model you pick — service bulletins, campaigns, warranty extensions, over-the-air notices, every model year. Nothing else is sent; one-click unsubscribe in every message. Separate from recall alerts.
What owners reported
Source: NHTSA complaint databaseOwners of the 2 model years this bulletin names have filed 54 complaints with NHTSA since 2015. 11 of them name Power Train — the same broad component group this bulletin is filed under. NHTSA groups complaints coarsely, so that means the same area of the vehicle, not necessarily the same fault.
The High-Pressure Fuel Pump (HPFP) and corresponding fuel delivery pressure regulator/sensors have suffered an internal mechanical failure. The system intermittently fails to maintain commanded rail pressure, leading to critical engine cylinder misfires (P0302, P0304) and severe long-term fuel adaptation breaches (P00C600, P008992…
2023 Mercedes-Benz Sprinter · Power Train · filed with NHTSA Oct 11, 2026 · ODI 11770454
A complaint is one owner’s account, not a defect finding, and a bulletin is not a recall. Nothing here says this bulletin was issued because of these complaints, or that the repair it describes fixed them. Complaint files on this site begin in 2015.
More bulletins about the power train
Source: same model, same component group12 other manufacturer communications filed against the Mercedes-Benz Sprinter under the same component group (power train), newest first. The eight newest are listed; the rest are on the Mercedes-Benz list.
| Number | Kind | Dated | NHTSA’s summary |
|---|---|---|---|
| LI27_20_N_080998_1 | Service bulletin | Sep 25, 2026 | Sprinter 907 with 725.0 (NAG3 Classic) Transmission ‑ Shudder during acceleration Complaint Shudder may be felt in the following situations:… |
| LI28_00-N-079097_1_en | Service bulletin | Aug 26, 2026 | Complaint While driving through muddy / sandy/ off road terrain "4Matic Currently Unavailable" message on the dash Cause This vehicle is not… |
| LI20_10-N-080868_1_en | Service bulletin | Aug 6, 2026 | Complaint The coolant warning lamp may be displayed in the instrument cluster. The malfunction indicator lamp (MIL) may also be illuminated.… |
| LI18_40-N-080867_1_en | Service bulletin | Aug 5, 2026 | OM654 Engine Oil Consumption Complaint The customer may report repeated low engine oil level warnings in the instrument cluster. The custome… |
| LI33_30-N-080795 | Service bulletin | Jul 17, 2026 | Model 907 with all-wheel drive (A4M) – All-wheel drive inoperative Complaint The customer may report one or more of the following: • All-whe… |
| LI09_40-N-079144 | Service bulletin | Jun 29, 2026 | Complaint The check engine light is activated, accompanied by one or more of the following fault codes related to the Boost Pressure Positi… |
| LI00.20-N-080626 | Service bulletin | Jun 2, 2026 | Complaint ASSYST values in XENTRY actual values and workshop menu of instrument cluster are implausibly excessive. Infor-mation: According… |
| LI35.00-N-080267_1 | Service bulletin | May 26, 2026 | Sprinter 907 - Rear Axle Noise Diagnosis Best Practices Complaint Various noises from area of rear axle while driving Cause A: Howling Noise… |
Quote the number at the service desk. It is what the dealer’s system is keyed on.
Every manufacturer communication NHTSA holds for Mercedes-Benz, by the number printed on the letter.
Common questions
Source: NHTSA, 49 CFR 579.5Is Mercedes-Benz LI27.00-N-078611 a recall?
No. A service bulletin is a manufacturer communication filed with NHTSA under 49 CFR 579.5; a safety recall carries an NHTSA campaign number (two digits, a letter, six digits) and a federal duty to repair for free. Check the vehicle’s recalls by VIN at nhtsa.gov/recalls, or on its page here.
Is the LI27.00-N-078611 repair free?
Not automatically. A service bulletin describes how to diagnose or repair a condition; who pays depends on the warranty in force, any extension, and the dealer. Quoting the number can save a diagnosis either way. Every Mercedes-Benz warranty extension on file lists the ones Mercedes-Benz has filed.
Which vehicles does LI27.00-N-078611 cover?
The manufacturer filed it against 2 model years: 2024 Mercedes-Benz Sprinter, 2023 Mercedes-Benz Sprinter. Whether one particular vehicle is affected is a matter of its VIN and its build, not its model year alone.