Ford bulletin SSM 52219
What it saysSome 2023-2024 Escape vehicles built on or before 11-Jan-2024 equipped with 1.5L engines may exhibit an Engine Coolant Over-Temperature Warning message displayed in the IPC and an illuminated malfunction indicator lamp… NHTSA’s full summary ↓
Ford filed this with NHTSA as a service bulletin dated Jan 30, 2024, received Feb 6, 2024, about the engine. It names 2 model years (2023–2024). A service bulletin is not a safety recall: it is the manufacturer telling its dealers how to diagnose or repair a condition, and whether the work is paid for depends on the warranty in force. Quoting the number at a service desk can save a diagnosis.
Get the next Ford Escape bulletin by email Weekly, only when something new is filed. Nothing else; one-click unsubscribe.
What the bulletin says
Source: NHTSA's summary of the manufacturer's communicationWhat it applies to, as the document itself states it — the build window in the manufacturer’s own words, read by machine from the PDF NHTSA serves. The build date is on the certification label in the driver’s door jamb; the dealer settles a borderline vehicle by its VIN.
Some 2023-2024 Escape vehicles built on or before 11-Jan-2024 equipped with 1.5L engines may exhibit an Engine Coolant Over-Temperature Warning message displayed in the IPC and an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P1285 and/or P1299 stored in the powertrain control module (PCM) during hard acceleration or under high load conditions. This may be due to machining chips trapped in the cylinder head causing a potential blockage in the coolant passage near the cylinder head temperature (CHT2) port. To diagnose this condition, start the vehicle and idle for 15 minutes. Perform a road test at a temperature above -20°C (-4°F) and apply wide-open throttle (WOT) hard accelerations in rapid succession. If the concern can not be replicated, drain and refill the coolant system. If the concern can be replicated, drain the coolant system. Disconnect the charge air cooler inlet and outlet hose, overflow hose, upper and lower hose of the radiator and position these components aside. Disconnect the inlet and outlet coolant hoses of the heater core and position these compone
Trouble codes it names: P1285 P1299
Document filed under this number
| Document | Kind | Dated | NHTSA id | At NHTSA |
|---|---|---|---|---|
| SSM 52219 | Service bulletin | Jan 30, 2024 | 10249778 | PDF, 62 KB |
The summary is NHTSA’s abstract of the document, as filed under 49 CFR 579.5. One communication is usually filed as several documents — the bulletin, a dealer notice, an owner letter — and the number on any of them finds this page. A PDF link is shown only once NHTSA’s own server has been seen to serve that document; the rest are checked over the following nights. Quote the number at a service desk; it is what the dealer’s system is keyed on.
Model years it names
Source: as the manufacturer filed themA vehicle page’s bulletin list shows the newest few communications filed against that model year; the count there is every one.
Email me new Ford bulletins for the Escape
A weekly email, sent only in a week when Ford files something new with NHTSA for the model you pick — service bulletins, campaigns, warranty extensions, over-the-air notices, every model year. Nothing else is sent; one-click unsubscribe in every message. Separate from recall alerts.
What owners reported
Source: NHTSA complaint databaseOwners of the 2 model years this bulletin names have filed 220 complaints with NHTSA since 2015. 50 of them name Engine — the same broad component group this bulletin is filed under. NHTSA groups complaints coarsely, so that means the same area of the vehicle, not necessarily the same fault.
Failed to shift into reverse. Seems to run some sort of safety check. Still does not reverse Dash active and showing messages from safety check - lights work. Wont shift into reverse. Car is parked in garage where it has been for previous 14 hours.
2023 Ford Escape · Engine · filed with NHTSA Nov 26, 2024
While accelerating the Vehicle I felt a massive kickback via the gas pedal, I was able to drive for half a mile more before the vehicle would no longer accelerate at all. The gas pedal was no working.
2024 Ford Escape · Engine · filed with NHTSA Jul 30, 2025
A complaint is one owner’s account, not a defect finding, and a bulletin is not a recall. Nothing here says this bulletin was issued because of these complaints, or that the repair it describes fixed them. Complaint files on this site begin in 2015.
More bulletins about the engine
Source: same model, same component group25 other manufacturer communications filed against the Ford Escape under the same component group (engine), newest first. The eight newest are listed; the rest are on the Ford list.
| Number | Kind | Dated | NHTSA’s summary |
|---|---|---|---|
| 25M03 | Other | Aug 18, 2026 | Customer Satisfaction Program 25M03 Certain 2020-2025 Model Year Escape, 2021-2025 Model Year Corsair and 2022- 2025 Model Year Maverick Veh… |
| 25B33 | Other | Jun 1, 2026 | Certain 2023-2025 Model Year Escape and Corsair, 2024-2025 Model Year Nautilus, 2025-2026 Model Year Bronco Sport and 2025 Model Year Maver… |
| 25B51 | Other | May 9, 2026 | Certain 2021-2024 Model Year Bronco, 2021-2024 Model Year Bronco Sport, 2020-2022 Model Year Corsair and Escape, 2016-2024 Model Year Explor… |
| SSM 54738 | Service bulletin | Apr 13, 2026 | Some 2023-2025 Escape 1.5L/F-Super Duty/Transit vehicles may exhibit a lack of cooling from the heating, ventilation, and air conditioning… |
| SSM 54631 | Service bulletin | Mar 6, 2026 | Some 2020-2026 Escape and 2022-2026 Maverick 2.5L Duratec hybrid vehicles may require various repairs on the exhaust system. This may requir… |
| SSM 54540 | Service bulletin | Jan 31, 2026 | Some 2025-2026 Escape/Bronco Sport vehicles equipped with a 1.5L EcoBoost engine may require replacement of the engine thermostat due to var… |
| 25N03 | Other | Oct 15, 2025 | Customer Satisfaction Program 25N03 Certain 2021-2023 Model Year Bronco Sport and 2020-2022 Escape with 1.5L Engine and 8F35 Transmission.… |
| 25H03 | Other | Sep 3, 2025 | Harvest Program 25H03 Certain 2024 - 2025 Model Year Bronco, Bronco Sport, Corsair, Escape, Explorer, Maverick, Mustang, and Ranger Vehicle… |
Quote the number at the service desk. It is what the dealer’s system is keyed on.
Every manufacturer communication NHTSA holds for Ford, by the number printed on the letter.
Common questions
Source: NHTSA, 49 CFR 579.5Is Ford SSM 52219 a recall?
No. A service bulletin is a manufacturer communication filed with NHTSA under 49 CFR 579.5; a safety recall carries an NHTSA campaign number (two digits, a letter, six digits) and a federal duty to repair for free. Check the vehicle’s recalls by VIN at nhtsa.gov/recalls, or on its page here.
Is the SSM 52219 repair free?
Not automatically. A service bulletin describes how to diagnose or repair a condition; who pays depends on the warranty in force, any extension, and the dealer. Quoting the number can save a diagnosis either way.
Which vehicles does SSM 52219 cover?
The manufacturer filed it against 2 model years: 2024 Ford Escape, 2023 Ford Escape. Whether one particular vehicle is affected is a matter of its VIN and its build, not its model year alone. The document itself sets the build window: 2023-2024 Escape: built on or before 11 Jan 2024 — the build date is on the certification label in the driver’s door jamb.