Jeep bulletin 9100401REV1
What it says3.5" speaker assembly Before replacing a speaker part for crackles or rattling noises make sure to take the following steps: 1. NHTSA’s full summary ↓
Jeep filed this with NHTSA as a service bulletin dated Aug 20, 2024, received Aug 26, 2024, about the electrical system. It names 4 model years (2023–2024). A service bulletin is not a safety recall: it is the manufacturer telling its dealers how to diagnose or repair a condition, and whether the work is paid for depends on the warranty in force. Quoting the number at a service desk can save a diagnosis.
Get the next Jeep bulletin for your model by email Weekly, only when something new is filed. Nothing else; one-click unsubscribe.
What the bulletin says
Source: NHTSA's summary of the manufacturer's communication3.5" speaker assembly Before replacing a speaker part for crackles or rattling noises make sure to take the following steps: 1. Check for electrical harness routing too close to speaker's rear moving parts, improper connection, and/or harness pinch or damage. 2. Ensure no loose components, including trim grilles, fasteners, surrounding IP parts, etc. were found when removing the speaker. 3. Try "bad" speaker at another IP location and see if noise follows speaker. Try a different "good" speaker at "bad speaker location" and see if noise still happens at "bad" location. 4. Remove the bad speaker and replace it back. 5. If even with this verification and adjustments the speaker sounds bad, test the individual speaker with the audio files provided in the Service Library Homepage under "Reference Materials" prior to replacement. Follow all these steps, if issue still happens; reach out to the engineer at Stellantis for more support, if the engineer doesn t respond in 30 minutes. Then the speaker can be replaced.
Document filed under this number
| Document | Kind | Dated | NHTSA id | At NHTSA |
|---|---|---|---|---|
| 9100401REV1 | Service bulletin | Aug 20, 2024 | 11006630 | PDF, 56 KB |
The summary is NHTSA’s abstract of the document, as filed under 49 CFR 579.5. One communication is usually filed as several documents — the bulletin, a dealer notice, an owner letter — and the number on any of them finds this page. A PDF link is shown only once NHTSA’s own server has been seen to serve that document; the rest are checked over the following nights. Quote the number at a service desk; it is what the dealer’s system is keyed on.
Model years it names
Source: as the manufacturer filed themA vehicle page’s bulletin list shows the newest few communications filed against that model year; the count there is every one.
Email me new Jeep bulletins for one of these models
A weekly email, sent only in a week when Jeep files something new with NHTSA for the model you pick — service bulletins, campaigns, warranty extensions, over-the-air notices, every model year. Nothing else is sent; one-click unsubscribe in every message. Separate from recall alerts.
What owners reported
Source: NHTSA complaint databaseOwners of the 4 model years this bulletin names have filed 300 complaints with NHTSA since 2015. 146 of them name Electrical System — the same broad component group this bulletin is filed under. NHTSA groups complaints coarsely, so that means the same area of the vehicle, not necessarily the same fault.
While driving the Wagoneer it shut down in the middle of road while at a stop light, and did a “hard” reset where all the systems had to boot back up before being able to start the Jeep. I reached out to local Jeep and to Service, and was told to bring it down so that they could run a scan.
2024 Jeep Wagoneer · Electrical System · filed with NHTSA Nov 1, 2026 · ODI 11774976
I bought this vehicle used form Carmax, <12000 miles. Drove about 12 miles, when while parking I noticed the car stopped and asked to start engine and engage gear again. Didn't think much of it. Then started driving again and the check engine light turned on.
2023 Jeep Wagoneer · Electrical System · filed with NHTSA Oct 12, 2024 · ODI 11619503
While driving my 2023 Grand Wagoneer the Serv 4WD light and dash spelled out Service four wheel drive, it lit up the anti collision light, ECS, TCS, and HOLD!. The parking brake also engaged automatically while driving at least 4 times.
2023 Jeep Grand Wagoneer · Electrical System · filed with NHTSA Jul 14, 2025 · ODI 11673436
In depth: 2024 Jeep Wagoneer electrical problems → · 2023 Jeep Wagoneer electrical problems →
A complaint is one owner’s account, not a defect finding, and a bulletin is not a recall. Nothing here says this bulletin was issued because of these complaints, or that the repair it describes fixed them. Complaint files on this site begin in 2015.
More bulletins about the electrical system
Source: same model, same component group280 other manufacturer communications filed against these Jeep models under the same component group (electrical system), newest first. The eight newest are listed; the rest are on the Jeep list.
| Number | Kind | Dated | NHTSA’s summary |
|---|---|---|---|
| 08-405-26 | Service bulletin | Oct 24, 2026 | Flash: Body Control Module (BCM) Update Customers may comment on the following: SYMPTOM: ● Driver and passenger doors do not lock or unlock… |
| 08-404-26 | Service bulletin | Oct 24, 2026 | Flash: Radio Frequency Hub Module (RFHM) Update Customers may comment on the following: SYMPTOM: ● Driver and passenger doors do not lock or… |
| 08-403-26 | Service bulletin | Oct 24, 2026 | Flash: Body Control Module (BCM) Update Customers may comment on the following: SYMPTOM: ● Driver and passenger doors do not lock or unlock… |
| 08-402-26 | Service bulletin | Oct 24, 2026 | Flash: Radio Frequency Hub Module (RFHM) Update Customers may comment on the following: SYMPTOM: ● Driver and passenger doors do not lock or… |
| S2508000037 REV. A | Service bulletin | Oct 22, 2026 | No Start, Passive Entry Inoperative |
| 9100944 | Service bulletin | Oct 15, 2026 | FUSE BLOCK RR - PWR DISTRIBUTI A/C Blowing hot air or not working. A/C relay clutch not operating, dealers are unnecessary replacing PDCs. B… |
| 9100943 | Service bulletin | Oct 15, 2026 | FUSE BLOCK UNDERHOOD - PWR DIS A/C Blowing hot air or not working. A/C relay clutch not operating, dealers are unnecessary replacing PDCs. B… |
| 08-375-26 | Service bulletin | Oct 14, 2026 | Tow Nav Menu Option Unavailable - UBQ/UBW Customers may comment on the following: SYMPTOM: ● Tow Nav menu option is grayed out and cannot be… |
Quote the number at the service desk. It is what the dealer’s system is keyed on.
Every manufacturer communication NHTSA holds for Jeep, by the number printed on the letter.
Common questions
Source: NHTSA, 49 CFR 579.5Is Jeep 9100401REV1 a recall?
No. A service bulletin is a manufacturer communication filed with NHTSA under 49 CFR 579.5; a safety recall carries an NHTSA campaign number (two digits, a letter, six digits) and a federal duty to repair for free. Check the vehicle’s recalls by VIN at nhtsa.gov/recalls, or on its page here.
Is the 9100401REV1 repair free?
Not automatically. A service bulletin describes how to diagnose or repair a condition; who pays depends on the warranty in force, any extension, and the dealer. Quoting the number can save a diagnosis either way. Every Stellantis warranty extension on file lists the ones Stellantis has filed.
Which vehicles does 9100401REV1 cover?
The manufacturer filed it against 4 model years: 2024 Jeep Grand Wagoneer, 2023 Jeep Grand Wagoneer, 2024 Jeep Wagoneer, 2023 Jeep Wagoneer. Whether one particular vehicle is affected is a matter of its VIN and its build, not its model year alone.